news & press

How to Clean an Airless Paint Sprayer

Proper cleaning of an airless sprayer like the RONGPENG R450 is crucial for maintaining its performance and extending its lifespan. Here is a detailed guide on how to clean it effectively.

Preparation
Before starting the cleaning process, make sure to turn off the sprayer and unplug it from the power source. This is to ensure safety during the cleaning process. Also, gather the necessary cleaning materials, including a bucket, water or mineral spirits (depending on the type of paint used), a brush, and clean rags.

Pressure Relief
1.Turn OFF power and turn pressure control to lowest pressure setting.
2.Hold gun against side of grounded metal flushing pail. Trigger gun to relieve pressure.

3.Turn prime valve down. Our pressure relief should by operate by hand.

4.If you suspect the spray tip or hose is clogged or that pressure has not been fully relieved after following the steps above, VERY SLOWLY loosen tip guard retaining nut or hose end coupling to relieve pressure gradually, then loosen completely. Clear hose or tip obstruction.
5.Engage trigger safety lock on gun if unit is being shut down or left unattended.

Disassembly
1.Remove the Spray Gun and Nozzle : Take off the spray gun and nozzle from the sprayer. This will allow you to clean them separately and more thoroughly.
2.Remove the Paint Hose : Disconnect the paint hose from the sprayer and the paint container. This will prevent any remaining paint from drying and clogging the hose.

Cleaning the Spray Gun and Nozzle
1.Rinse with Water or Mineral Spirits : If you were using water - based paint, rinse the spray gun and nozzle with clean water. For oil - based paint, use mineral spirits. Hold the spray gun over the bucket and pull the trigger to let the cleaning liquid flow through the gun and nozzle until it comes out clean.
2.Scrub with a Brush : Use a brush to scrub the spray gun and nozzle, paying special attention to the nozzle tip and the areas around it where paint residue may accumulate. Make sure to remove all the paint residue to ensure a smooth spray pattern next time you use the sprayer .

Cleaning the Paint Hose
1.Rinse with Water or Mineral Spirits : Immerse the paint hose in the bucket of water or mineral spirits and let it soak for a while. Then, use a brush to scrub the inside of the hose to remove any remaining paint.
2.Rinse Again : After scrubbing, rinse the hose again with clean water or mineral spirits to make sure all the paint residue is removed. Squeeze the hose gently to help the cleaning liquid flow through it.

Cleaning the Sprayer Body
1.Wipe with a Rag : Use a clean rag to wipe the exterior of the sprayer body, removing any paint splatters or dirt. Pay attention to the areas around the motor and the pump, as these are crucial components that need to be kept clean.
2.Clean the Pump : If the pump is accessible, you can use a brush to clean it. Be careful not to damage any parts of the pump during the cleaning process. Also, make sure the pump is dry before reassembling the sprayer.

Reassembly and Storage
1.Reassemble the Sprayer : After all the parts have been cleaned and dried, reassemble the sprayer. Make sure all the connections are tight and secure.
2.Store Properly : Store the sprayer in a dry and ventilated place. If you are not going to use it for a long time, it is recommended to run some mineral spirits through the sprayer to leave a protective coating and prevent corrosion .

Regular Maintenance
In addition to regular cleaning, it is also important to perform regular maintenance on the RONGPENG R450. This includes checking the oil level in the motor, lubricating the moving parts, and replacing any worn - out parts. By doing so, you can ensure the sprayer is always in good working condition and ready for your next painting project.
In conclusion, cleaning a airless sprayer like the AEROPRO R450 is not a difficult task, but it requires attention to detail and regular maintenance. By following the steps outlined above, you can keep your sprayer in top - notch condition and enjoy smooth and efficient painting every time.

We also have other air tools, welcome to contact us:rongpeng@rongpeng.com
For more information you can contact with Whatsapp:+86 13906596225